Mahle-rti TX200 Manuel d'utilisateur

Operation&MaintenanceManualTX200RTI Technologies, Inc.10 Innovation DriveYork, Pennsylvania, USA 17402Telephone: 717-840-0678Fax: 717-755-8304Web-

Page 9 NON-CONDENSABLE PURGE CHART (BARS)0C R12 R22 R502 R134a0 3.03 5.45 6.34 2.901 3.15 5.63 6.59 3.012 3.28 5.79 6.76 3

Page 10Procedure for Clearing TX200 between RefrigerantsThe TX200 can be used to recover many different refrigerants. If the recovered refrigerantsare

Page 11VERY IMPORTANTThe TX200 requires that 2 ounces (60ml) of compressor oil be added afterevery 25 hours of operation. This oil replaces the oil re

Page 12SPR ADJUSTMENTThe TX200 has been factory adjusted and tested for optimum performance at operatingtemperatures from 10 to 490 C. Adjustment of t

Page 13PROBLEMS & SOLUTIONSOn rare occasion the TX200 may seem to be performing differently or not at all. Experiencehas shown that varying operat

Page 14ACCESSORY PARTS LIST

Page 15

Page 16

Page 1! TABLE OF CONTENTS !TX200Before Using The TX200 ...2Warranty ...2Safety Precautions .

Page 2BEFORE USING THE TX200Check for any shipping damage. Place a claim with carrier if damage is discovered.DO NOT USE A DAMAGED UNIT.The TX200 shou

Page 3SAFETY PRECAUTIONS! Recover R12, R22, R134a or R502 Refrigerant only.! Wear safety glasses and protective gloves. Refrigerant has a very low boi

Page 4RECOVERY MODEFigure 1: Shows the recommended connection of the TX200 to an A/C System.CAUTION...For large capacity systems it is recommended tha

Page 5Connect TX200 Power Cord to a properly protected, grounded receptacle. Avoid using anextension cord. If necessary, use a good condition, 3-wire

Page 6Allow this sequence to repeat until the Compressor-On Light remains off continuously forat least 2 minutes.The DEEP VACUUM Switch can be pressed

Page 7Procedure for Fast RecoveryThe goal of any technician is to recover all the refrigerant from an A/C system in as shorta time as possible. This r

Page 8PURGING AIR FROM THE ERC CYLINDERRefrigerant recovered into the ERC Cylinder may also contain Air. This Air will increase thepressure in the ERC